Champion Power Equipment 41153 Manuale del Proprietario

41153 Rev 41153-20100604 www.championpowerequipment.com 10006 Santa Fe Springs Road Santa Fe Springs, CA 90670 USA Made in China 6500 Peak Watts/55

Controls and Features Rev 41153-20100604 E 7 Parts Included Your 41153 Gasoline Powered Generator ships with the following parts: Wheel Kit 10

Assembly 8 Rev 41153-20100604 E Assembly Your generator requires some assembly. This unit ships from our factory without oil. It must be properly s

Assembly Rev 41153-20100604 E 9 Add Engine Oil CAUTION DO NOT attempt to crank or start the engine before it has been properly filled with the

Assembly 10 Rev 41153-20100604 E Grounding Your generator must be properly connected to an appropriate ground to help prevent electric shock. WARN

Operation Rev 41153-20100604 E 11 Operation Generator Location Please consult your local authority. In some areas, generators must be registere

Operation 12 Rev 41153-20100604 E Stopping the Engine 1. Turn off and unplug all electrical loads. Never start or stop the generator with electric

Operation Rev 41153-20100604 E 13 Wattage Reference Chart Use the chart to determine approximate wattage requirements for your equipment. NO

Maintenance 14 Rev 41153-20100604 E Maintenance The owner/operator is responsible for all periodic maintenance. WARNING Never operate a damaged o

Maintenance Rev 41153-20100604 E 15 Air Filter 1. Remove the snap-on cover holding the air filter to the assembly. 2. Remove the foam element

Storage 16 Rev 41153-20100604 E Storage The generator should be started at least once every 14 days and allowed to run for at least 20 minutes. For

Specifications Rev 41153-20100604 E 17 Specifications Engine Specifications Engine 338 cc OHV CPE Generator Specifications Running Wattage 55

Specifications 18 Rev 41153-20100604 E Parts Diagram

Specifications Rev 41153-20100604 E 19 Parts List Item Part Number Description Qty. 1 5P3 Control panel 1 2 DP03-00000000-2 Intelliguage 1 3

Specifications 20 Rev 41153-20100604 E Item Part Number Description Qty. 53 GB818 M5X14 Flange Bolt M5"14 2 54 ST188FD-1730100 Muffler gasket

Specifications 21 Wiring Diagram Rev 41153-20100604 E

Troubleshooting 22 Rev 41153-20100604 E Troubleshooting Problem Cause Solution No fuel Add fuel Faulty spark plug Replace spark plug Generator will

Warranty 23 Warranty CHAMPION POWER EQUIPMENT 2 YEAR LIMITED WARRANTY Effective September 1, 2006. Replaces all undated warranties and all warrant

Warranty 24 Champion Power Equipment, Inc (CPE), Emission Control System Warranty Your Champion Power Equipment (CPE) engine complies with Enviro

Warranty 25 EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System Warranty Coverage. E

Warranty 26 i. Unapproved add-on or modified parts may not be used to modify or repair a CPE engine. Such use voids this ECS Warranty and shall b

Table of Contents Introduction... 1!Portable Power Generator ... 1!Accessories ...

Introduction Rev 41153-20100604 E 1 Introduction Congratulations on your purchase of a Champion Power Equipment generator. CPE designs and buil

Manual Conventions 2 Rev 41153-20100604 E Manual Conventions This manual uses the following symbols to help differentiate between different kinds o

Safety Rules Rev 41153-20100604 E 3 Safety Rules WARNING Read this manual thoroughly before operating your generator. Failure to follow inst

Safety Rules 4 Rev 41153-20100604 E DANGER Fuel and fuel vapors are highly flammable and extremely explosive. Fire or explosion can cause severe b

Controls and Features Rev 41153-20100604 E 5 Controls and Features Read this owner’s manual before operating your generator. Familiarize yourse

Controls and Features 6 Rev 41153-20100604 E Power Panel (1) Intelligauge – Three mode digital meter for running hours, voltage and hertz. (2)